STILL electric forklifts (counterbalance)

STILL electric counterbalance forklifts for loads from 1 to 8 tonnes

This category covers the STILL electric forklift range – counterbalance trucks distributed by TCID in Vietnam, from compact trucks working inside containers to heavy-duty models replacing diesel trucks in the yard. All share zero local emissions, low noise and the ability to work in enclosed halls and outdoors; they differ in capacity, lift height, speed and duty level.

The range splits into three groups: compact (SXV-CB 10, RXE 10 – 16C) for tight aisles and containers; high-performance (RX 20, three RX 60 versions) for multi-shift warehouses; and Classic Line (RCE 15 – 20, RCE 25 – 35), easy to service, for low- and medium-intensity work.

Comparing the models in this category

Figures come from each range's model table; actual lift height depends on the mast selected.

Model range	Maximum capacity (kg)	Maximum lift height (mm)	Travel speed (km/h)	Battery voltage (V)
STILL SXV-CB 10	1,000	5,380	12	24
STILL RXE 10 – 16C	1,000 – 1,600	5,610 – 6,810	12	24
STILL RX 20	1,400 – 2,000	7,720 – 7,930	20	48
STILL RCE 15 – 20	1,500 – 2,000	6,500	15 – 16	80
STILL RCE 25 – 35	2,500 – 3,500	6,500	15	80
STILL RX 60 2.5 – 3.5 t	2,500 – 3,500	7,390	20	80
STILL RX 60 3.5 – 5.0 t	3,500 – 4,990	6,880 – 7,180	19 – 20	80
STILL RX 60 6.0 – 8.0 t	6,000 – 8,000	7,705 – 8,670	20	80

Equal capacity does not mean interchangeable: RCE 25 – 35 and RX 60 2.5 – 3.5 t both lift 3,500 kg, but the RX 60 lifts higher, drives faster and suits high-intensity duty, while the RCE prioritises simplicity for occasional stacking.

Choosing an electric forklift by capacity and working space

Light loads, tight aisles

The SXV-CB 10 lifts 1,000 kg on cantilever forks, has a small turning radius and automatically limits speed when cornering. The RXE 10 – 16C, the smallest member of the RX family, is just under 2 metres high and about 1 metre wide, so it works inside trucks and containers while still lifting close to 7 metres.

The popular 1.4 – 3.5 tonne segment

This is the most requested group. The STILL RX 20 features the STILL Easy Control on-board computer, side battery change and a top speed of 20 km/h, making it a good fit for warehouses with continuous handling. The RCE 15 – 20 comes in three-wheel and four-wheel versions and uses a standard lithium-ion battery with a side quick-charge port. Businesses looking specifically at a 2-ton electric forklift or a 3-ton electric forklift can read the dedicated guide for each capacity.

Heavy loads, replacing diesel

The RX 60 3.5 – 5.0 t works both in the warehouse and outdoors, even in the rain; with STILL lithium-ion technology it can run three shifts without a battery change. The STILL RX 60 6.0 – 8.0 t is the flagship range: the RX 60-80/900 lifts eight tonnes at a 900 mm load centre in a working aisle of only 4,999 mm, with a standard top speed of up to 17 km/h and up to 20 km/h in the optional sprint mode.

Before settling on a model, check the following points:

• The heaviest load and the actual load centre with long forks or clamps.
• The top racking level and clearance height of doors and containers.
• Aisle width and floor type: flat concrete, ramps or outdoor yard.
• Number of shifts per day and the breaks available for charging.
• Special environments: wet, dusty, cold storage or explosion-risk areas (RX 20 and RX 60 2.5 – 5.0 t have explosion-protected versions).

If you are still weighing electric against internal combustion, the article electric vs diesel forklift compares both by working environment. For three-wheel versus four-wheel configurations of the smaller models, see our comparison of RCE, RXE and SXV-CB.

Lead-acid battery or lithium-ion

The energy source determines run time, charging method and the infrastructure needed; depending on the model, trucks use lead-acid or lithium-ion batteries. Lead-acid suits single-shift trucks with time for a full charge; lithium-ion allows opportunity charging during breaks, needs no watering and suits multiple shifts. Choosing capacity, charging and storage are covered in detail in our article on the forklift battery.

Investment and operating costs

The price of an electric truck depends on the model range, mast type, lift height, battery type and safety options such as the STILL SafetyLight 4plus. For that reason TCID does not publish a single list price but quotes based on the actual configuration. Compare total cost of ownership (energy, maintenance, downtime, battery life) rather than purchase price alone. Businesses looking for an affordable electric forklift can consider a right-sized configuration, term rental or a carefully inspected used truck.

Frequently asked questions

Can an electric forklift be used outdoors?

Yes. The RX 60 ranges are designed for both indoor and outdoor use, even in wet weather; the RX 60 6.0 – 8.0 t works in wet and dusty environments. The RCE 25 – 35 offers a fully enclosed cab option for outdoor use.

Which model is suitable for working inside containers?

The RXE 10 – 16C is designed to work inside trucks, containers and narrow aisles thanks to its compact dimensions. The SXV-CB 10 is another option for confined spaces with loads up to 1,000 kg.

Can one truck run several shifts continuously?

Yes, with the right energy source. The RX 20 and RX 60 support side battery change; the lithium-ion version of the RX 60 3.5 – 5.0 t can run three shifts without a battery change.